Results 1 to 5 of 5

Thread: HID Aftermarket legality!!

  
  1. #1
    Status
    Offline
    Wooly MK4's Avatar
    AOC Newbie
    Join Date
    May 2003
    Posts
    37
    Mentioned in
    0 Post(s)
    Quoted
    0 Post(s)

    HID Aftermarket legality!!

    Fact sheet: Aftermarket HID headlamps
    December 2006
    In the Department's view it is not legal to sell or use after market HID lighting kits, for converting conventional Halogen headlamps to HID Xenon. If a customer wants to convert his vehicle to Xenon HID he must purchase completely new Xenon HID headlamps. The reason for this is that the existing lens and reflector are designed around a Halogen filament bulb, working to very precise tolerances. If one places a HID "burner" (bulb) in the headlamp, the beam pattern will not be correct, there will be glare in some places and not enough light in other places within the beam pattern.

    The following is the legal rationale:

    The Road Vehicle Lighting Regulations 1989 regulate the situation in the UK.
    Under these Regulations, HID/Gas Discharge/Xenon headlamps are not mentioned and therefore they are not permitted according to the strict letter of the law.

    However new vehicles have HID headlamps. This is because they comply to European type approval Regulations. The UK cannot refuse to register a vehicle with a European type approval. These are to ECE Regulation 98 (for the HID headlamps which are tested on a rig in a laboratory) and ECE Regulation 48 (Lighting Installation on the vehicle).

    For the after market, a used vehicle cannot obtain type approval because it is only applicable for new vehicles. However we feel that saying "HID is banned in the after market" would not be reasonable. Instead we should make analogies with new vehicles. It would be reasonable to require HID in the after market to meet the same safety standards as on new vehicles. The same level of safety should apply.

    Therefore a HID headlamp unit sold in the after market should:

    1. be type approved to ECE Regulation 98 as a component.

    2. when fitted to the vehicle should enable ECE Regulation 48 to be complied with (although no government inspection will take place).

    3. Comply with RVLR as far as "use" is concerned.

    In practice this means:

    1. The headlamp unit (outer lens, reflector, bulb) shall be type approved to ECE 98 and be "e-marked" to demonstrate this. That can only be done by the headlamp supplier - Hella, Valeo etc. who must test the headlamp in an independent laboratory.

    2. Once fitted to the vehicle it must have headlamp cleaning and self-levelling (which can be for the headlamp or can be in the vehicle suspension - some expensive estate cars have "self-levelling suspension" and that is adequate). Also the dipped beam must stay on with the main beam.

    3. The headlamp must be maintained in good working order, kept clean, and aligned/adjusted correctly like any other headlamp.

    Under the Road Traffic Act 1988 it is an offence to supply, fit or use vehicle parts which are not legal.

    In summary it is not permitted to convert an existing halogen headlamp unit for use with HID bulbs. The entire headlamp unit must be replaced with one designed and approved for use with HID bulbs and it must be installed in accordance with the rules stated above.

    If you require any further information regarding the regulations covered by this fact sheet, please contact the DfT at the address below:

    Transport Technology and Standards 6
    Department for Transport
    Zone 2/04
    Great Minster House
    76 Marsham Street
    London
    SW1P 4DR

    Telephone: 020 7944 2078
    Fax: 020 7944 2196
    Email: TTS.enquiries@dft.gsi.gov.uk

  2. #2
    Status
    Offline
    lee gsi's Avatar
    AOC Obsessed
    Join Date
    Jul 2003
    Location
    Near Portsmouth....... Drives a Signum 1.9 CDTi
    Posts
    17,757
    Mentioned in
    0 Post(s)
    Quoted
    0 Post(s)
    Its been illegal for ages.

    But most MOT places have real people in and can see they are not a problem rather than some suited desk jockey thinking he knows best lol.
    The truth is always the truth even if you haven't realised it yet...

  3. #3
    Status
    Offline
    Toms1989's Avatar
    Soft Top VTEC :)
    Join Date
    Dec 2007
    Posts
    11,356
    Mentioned in
    0 Post(s)
    Quoted
    1 Post(s)
    Quote Originally Posted by lee gsi View Post
    Its been illegal for ages.

    But most MOT places have real people in and can see they are not a problem rather than some suited desk jockey thinking he knows best lol.
    Well put

    I have them in my motor, and have had no problems with the law, mainly as they're setup correctly, and not dazzling other drivers
    FULL Black Leather Heated coupe interior for sale! £200!!!
    Click Here

  4. #4
    Status
    Offline
    lee gsi's Avatar
    AOC Obsessed
    Join Date
    Jul 2003
    Location
    Near Portsmouth....... Drives a Signum 1.9 CDTi
    Posts
    17,757
    Mentioned in
    0 Post(s)
    Quoted
    0 Post(s)
    From a legal stand point you should even inform your insurance if you change tyres from the standard recommended fit from the factory.

    But again there are real people in this world.
    The truth is always the truth even if you haven't realised it yet...

  5. #5
    Status
    Offline
    bucky's Avatar
    AOC Obsessed
    Join Date
    May 2005
    Posts
    1,179
    Mentioned in
    0 Post(s)
    Quoted
    0 Post(s)
    bovvvvvvvvered.

Similar Threads

  1. HID legality?
    By wywywywy in forum Astra Discussion & Chat
    Replies: 15
    Last Post: 19-01-2007, 09:28
  2. Sidelight Legality???
    By SXiDave in forum Car Chat (other marques/models)
    Replies: 12
    Last Post: 18-11-2004, 00:23

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •